Gas Furnace Installation Checklist

Use this hvac maintenance checklist that includes sections for the maintenance of air conditioner heat pump electric heater gas furnace and dual fuel heat pump furnace.

Gas furnace installation checklist.

Make copies of the checklist and complete one for every low profile furnace service call for your records. A conversion kit ordered separately is re quired for use in propane lp gas applications. We specialize in commercial and residential furnace installation maintenance and repairs throughout toronto and the gta. Check all field wiring.

For example this installation manual has a start up checklist. Gas furnace replacement checklist inspection adjustments documents. Before beginning any troubleshooting procedure complete the following installation checklist. D a95uh a93uh 95g1uh 92g1uh warm air gas furnace upflow horizontal left and right air discharge start up checklist a multiple furnace installation may use a group of up to.

Warranty and manual in envelope attached to furnace agency given copy of sizing calculation photos documenting furnace conditions and manufacturer nameplate installation information sticker installer name phone number date. Iauditor templates can be edited to meet the needs of inspectors and technicians. Refer to 2018 irc chapter 24. High efficiency gas furnace pricing and installation cost checklist.

Provide sufficient space for service accessibility. A furnace malfunction is sometimes caused by an improper installation. The common connector pipe for category i gas furnaces is type b double wall and the metal pipe should be installed from the furnace to termination. Adjust primary air shutter.

The furnace is not to be used for temporary heating of buildings or structures under construction. The furnace is equipped for installation in natural gas ap plications. Furnace installation pre start checklist 27 start up procedures the installation instructions shall remain with the appliance or equipment at the completion of the installation. We ll make sure that every item on your gas induction and vacuum furnace checklist is properly ticked off to ensure maximum operational efficiency before winter comes.

By completing this checklist the problem may be found and corrected. Figure 11 51 and the following installation checklist is offered as a guide for the installer. A gas fired furnace for installation in a residential garage must be installed as specified in the location requirements section of these instructions. The ml193df can be installed as a direct vent or non direct vent.

Get at least 3 5 estimates before hiring a high efficiency gas furnace hvac contractor estimates are typically free unless it s a service call for a repair.